Product ID:801 METAL CONDITIONER
MSDS Date:06/05/1987
FSC:8010
NIIN:00F009816
MSDS Number: BHLQZ

BASF CORPORATION

6125 INDUSTRIAL PARKWAY
WHITEHOUSE, OH 43571

Emergency Phone: (419) 877-5308

Info Phone: (419) 877-5308

Preparer: B. M. RICHARDS

Cage: 0PK40

BASF CORPORATION

PARSIPPANY, NJ 07054 US

Telephone: 201-316-3000 OR 800-424-3900

Cage: 0PK40

0.0

RTECS: 9999999VO

PHOSPHORIC ACID (SARA III)

CAS: 7664-38-2

RTECS: TB6300000

OSHA PEL 1 MG/M3/3 STEL

ACGIH TLV: 1 MG/M3/3 STEL; 9192

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2-BUTOXYETHANOL

CAS: 111-76-2

RTECS: KJ8575000

OSHA PEL S, 50 PPM

ACGIH TLV: S, 25 PPM; 9293

Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: MAY CAUSE POSSIBLE
RESPIRATORY IRRITATION/CORROSIVE. EYE/SKIN: SEVERE BURNS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:PROLONGED OVERXPOSURE TO SOLVENT CAUSES
PERMANENT CENTRAL NERVOUS SYSTEM DEPRESSION. ABUSE MAY BE HARMFUL
OR FATAL.

First Aid:INHALATION: RESTORE BREATHING. REMOVE TO FRESH AIR. KEEP
WARM/QUIET. NOTIFY A PHYSICIAN. EYE: FLUSH W/COPIOUS AMOUNTS OF
RUNNING WATER FOR AT LEAST 15 MINS. TAKE TO PHYSICIAN FOR
DEFINITIVE MEDICAL TR EATMENT. SKIN: CLEAN & WASH AFFECTED AREA
W/WATER. REMOVE CONTAMINATED CLOTHING. INGESTION: INDUCE VOMITING.
CALL PHYSICIAN IMMEDIATELY.

Flash Point Method:SCC
Flash Point:152-162F
Lower Limits:1.0%
Upper Limits:10.6%
Extinguishing Media:FOAM, CO2, CHEMICAL POWDER, WATER MIST
Fire Fighting Procedures:FULL PROTECTIVE EQUIPMENT/SCBA. WATER SPRAY
MAY BE INEFFECTIVE. IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:WATER SPRAY MAY BE USED TO COOL CLOSED
CONTAINERS TO PREVENT PRESSURE BUILD-UP, & EXPLODE WHEN EXPOSED TO
EXTREME HEAT.

Spill Release Procedures:VENTILATE AREA. REMOVE ALL POSSIBLE SOURCES OF
IGNITION. CONFINED SPILL W/INERT ABSORBENT & CLEAN UP WITH
SPARK-PROOF TOOLS.

Handling and Storage Precautions:DON'T STORE NEAR OPEN FLAMES, HEAT,
BELOW FREEZING TEMP 32F. WHEN STORE LARGE QTYS, STORE IN BLDG
DESIGNED/PROTECTED AGAINST COMBUSTIBLE LIQUIDS.
Other Precautions:USE STATIC LINES WHEN MIXING/TRANSFERRING MATERIAL.
DON'T ALLOW MATERIAL TO FREE FALL >5 INCHES. FOR INDUSTRIAL USE
ONLY. DON'T TAKE INTERNALLY. DON'T FLAME CUT, WELD, OR BRAZE ON
COATED METAL W/O NIO SH/MSHA TC23C RESPIRATOR.

Respiratory Protection:USE NIOSH/MSHA TC23C CHEMICAL/MECHANICAL TYPE
SYSTEM TO REMOVE A COMBINATION OF PARTICLES OF OVERSPRAY, GAS, &
VAPOR. USE AIR LINE TYPE IF NECESSARY.
Ventilation:USE ADEQUATE MECHANICAL VENTILATION IN VOLUME/PATTERN TO
KEEP Protective Gloves:RUBBER
Eye Protection:SAFETY GLASSES, GOGGLES W/SIDESHIELDS.
Work Hygienic Practices:REMOVE CONTAMINATED CLOTHING. AVOID BREATHING
OF VAPORS.
Supplemental Safety and Health
WT PER GAL: 11.3 LBS

Boiling Pt:B.P. Text:336-344F
Vapor Pres:1.0
Vapor Density:Evaporation Rate & Reference:SLOWER THAN ETHER
Percent Volatiles by Volume:60-70%

Stability Indicator/Materials to Avoid:YES
STRONG ACID, ALKALIES, & OXIDIZERS
Stability Condition to Avoid:OPEN FLAMES, HEAT, ELECTRICAL EQUIPMENT &
STATIC DISCHARGE.
Hazardous Decomposition Products:CO2, CO, SMOKE & SMALL TRACES OF
ORGANIC SOLVENTS. COMBINATION OF PARTICLES OF OVERSPRAY, GAS &
VAPOR.

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE W/LOCAL, STATE, &
FEDERAL REGULATIONS. LAND FILL OR INCINERATE IN APPROVED FACILITY
BY LICENSED CONTRACTOR. DON'T INCINERATE IN CLOSED CONTAINER.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.